环氧地坪塗裝粗糙的由來及解決方法

一、施工环境和环氧地坪漆膜幹燥過程中的环境不幹凈，灰塵多，使灰塵落在還處於流平階段的漆膜上，最終導致灰塵黏附於环氧地坪漆塗膜上而使塗膜出現粗糙現象。二、环氧地坪塗料塗裝前沒有過濾，混入機械雜質，這些機械雜質與塗料一起被塗裝在瞭被塗物上，當塗膜幹燥後機械雜質就突顯在环氧地坪漆塗膜上瞭，最後導致塗膜出現瞭粗糙的現象。三、由於环氧地坪塗料是雙組分或多組分塗料，又屬於化學固化型塗料，所以當塗料混入固化劑後，塗料就開始起化學作用，环氧地坪塗料黏度就慢慢升高，到特定時間後就開始膠化，直接最後固化成膜。當塗料開始膠化仍繼續施工時，地坪漆塗膜就可能出現粗糙瞭。
1. The construction environment and the drying process of the epoxy floor paint film are not clean and dusty, which makes the dust fall on the film which is still in the leveling stage, and eventually causes 环氧地坪the dust to adhere to the floor paint film and make the film rough. 2. The epoxy floor coatings were not filtered before painting, and were mixed with mechanical impurities. These mechanical impurities were coated on the coatings together with the coatings. When the coatings were dried, the mechanical impurities were highlighted on the floor coatings, which eventually led to the appearance of rough coatings. 3. Because epoxy floor coatings are two-component or multi-component coatings, and belong to chemical curing coatings, when the coatings are mixed with curing agents, the coatings begin to play a chemical role, and the viscosity of epoxy floor coatings increases slowly. After a certain time, the coatings begin to gelatinize and then solidify directly into films. When the coating begins to gelatinize and continues to be applied, the film of floor paint may be rough.
四、施工現場溫度太高，稀釋劑揮發太快，环氧地坪漆塗料塗到被塗物上已經沒有流平的時間就已經開始固化，因此就會出現粗糙的現象。
Fourth, the construction site temperature is too high, the diluent volatilizes too fast, the epoxy floor paint coated on the coating has no leveling time has begun to solidify, so there will be rough phenomenon.
环氧地坪施工易被忽略的环節
Neglected links in epoxy floor construction
环氧樹脂地坪，不僅可以保護混凝土地面，還可以提高地坪表面的耐磨抗重抗壓性能，還能達到裝飾美觀、凈化無塵車間的效果。
Epoxy resin floor can not only protect concrete floor, but also improve the anti-wear, anti-weight and anti-compression performance of the floor surface. It can also achieve the effect of beautiful decoration and clean dust-free workshop.
环氧樹脂地坪的厚度很薄，它要承載表面的所有重壓，主要還是靠地坪基面來支撐，地坪基面的質量就是环氧樹脂地坪質量的重點。
The thickness of epoxy resin floor is very thin. It bears all the heavy pressure on the surface. It is mainly supported by the base of the floor. The quality of the base of the floor is the focus of the quality of the epoxy resin floor.
而基面的質量問題往往是很多人不重視的問題，甚至還常出現因忽視地坪漆基面的處理，而造成工程的質量隱患。
The quality of the base surface is often a problem that many people do not pay attention to, and even often there is a hidden quality hazard caused by neglecting the treatment of the base surface of floor paint.
下面因忽視地坪基面處理而造成工程印花地坪質量隱患的幾個原因：
Following are several reasons for the hidden danger of engineering quality caused by neglecting the treatment of ground surface:
1、甲方。甲方認為既然是混凝土地面弄好後，再在上面施工环氧地坪漆，那混凝土地面就不用太註重質量，差一點都無所謂。
1. Party A. Party A considers that since the concrete floor is finished and epoxy floor paint is applied on it, the concrete floor need not pay too much attention to quality, which is almost indifferent.
2、地坪基面施工隊。地坪基面施工隊認為，反正基面處理後會用环氧地坪漆蓋住，有點小問題甲方也看不出來，隨便弄就行。
2. Floor foundation construction team. The construction team believes that the ground surface will be covered with epoxy floor paint after treatment anyway. Party A can't see any minor problems, just do it anyway.
3、环氧地坪漆施工方。环氧地坪漆施工方對基面認識不足，與甲方溝通中未表達對基面的要求，施工中也不註意。或者同行競爭嚴重，再差的地坪基礎都接，做好收完款走人。導致人們對基面的重視意識越來越淡薄。
3. Construction side of epoxy floor paint. The Construction Party of epoxy floor paint does not know enough about the base surface, and does not express the requirements for the base surface in communication with Party A, nor does it pay attention to the construction. Or peer competition is serious, no matter how poor the foundation of the floor is, do a good job of collecting money and leaving. As a result, people's awareness of the importance of fundamentals is becoming weaker and weaker.
作為專業的地坪漆生產廠傢，混凝土基面處理不好，會導致环氧地坪漆的使用質量和使用年限下降，地坪漆弊病產生的幾率增加，甲方在使用环氧地坪漆的過程中會需要頻繁的返修。不停的影響使用體驗，和影響生產。對混凝土地面施工隊來說，最終追溯責任，還是要找到混凝土基面的施工方，最終仍是難逃責任。對地坪漆施工方而言，頻繁返修，消費的人力精力，並持續增加成本，會成為一個巨大的負擔。
As a professional floor paint manufacturer, poor treatment of concrete base will lead to the decline of the quality and service life of epoxy floor paint, increase the probability of floor paint defects, and Party A will need frequent repairs in the process of using epoxy floor paint. Continuously affect the use of experience, and affect production. For the concrete ground construction team, the ultimate retrospective responsibility, or to find the construction side of the concrete foundation, is still the ultimate responsibility. For floor paint builders, frequent repairs, consumption of human energy, and continuous increase in costs, will become a huge burden.
所以，在塗裝环氧樹脂地坪工程時，混凝土基面的質量，环氧塗層施工的質量都是工程的關鍵，不管是哪個环節出瞭問題，完工後的工程質量都會大打折扣。
Therefore, the quality of concrete base surface and the quality of epoxy coating construction are the key points in the epoxy floor coating project. Whatever link is wrong, the quality of the finished project will be greatly reduced.
因此：地坪漆施工方一定要註意混凝土基面的處理。
Therefore, the floor paint construction party must pay attention to the treatment of concrete base.