離心風機維護修理人員必須註意行業標準

為瞭避免由於維護不當而引起人為故障的發生，預防離心風機及電機各方面的自然故障及事故的發生，從而充分發揮設備的性能，延長設備的使用壽命，必須加強離心風機的維護。
離心風機維護人員必須註意下列各點：
1、隻有在離心風機設備完全正常情況下方可運轉。
2、如離心風機設備在檢修後開動時，則需註意離心風機各部位是否正常。
3、定期清除離心風機及氣體輸送管道內部的灰塵、污垢及水等雜質、並防止銹蝕。
4、對離心風機設備的修理，不許在運轉中進行。
In order to avoid human fault caused by improper maintenance and prevent natural faults and accidents in various aspects of centrifugal fan and motor, so as to give full play to the performance of the equipment and prolong the service life of the equipment, it is necessary to strengthen the maintenance of the centrifugal fan.
Centrifugal fan maintenance personnel must pay attention to the following points:
1, only under the condition that the centrifugal fan equipment is completely normal.
2, if centrifugal fan equipment starts after maintenance, attention should be paid to whether the parts of the centrifugal fan are normal.
3. Regularly remove impurities, dirt and water from centrifugal fans and gas pipelines, and prevent rust.
4. Repair of centrifugal fan equipment is not 环氧地坪allowed in operation.
離心風機正常運轉中需要的註意事項如下：
1、如發現流量過大，不符合使用要求，或短時間內需要較小的流量，可利用節流裝置進行調節。
2、對溫度計及油標的靈敏性定期檢查，並應控制軸承箱油位在規定的允許范圍內。
3、在離心風機的開車、停車或運轉過程中，如發現不正常現象時，應立即進行檢查。
4、對檢查發現的小故障，應及時查明原因，設法消除或處理，如小故障不能消除，或者發現大故障時，應立即進行檢查。
5、除每次拆修後，應更換潤滑油外，還應定期更換潤滑油。
6、對E式傳動的軸承座應定期（季度）檢查，清洗和補加潤滑油，以防軸承燒壞。
The following points for attention in the normal operation of centrifugal fans are as follows:
1, if the flow is too large, does not meet the requirements of use, or need less traffic in a short time, the throttle device can be adjusted.
2. Periodically check the sensitivity of the thermometer and oil standard, and control the oil level of the bearing box within the prescribed allowable range.
3. During the start-up, shutdown or operation of centrifugal fans, any abnormal phenomena should be checked immediately.
4. To check and find out the small faults, we should find out the reasons in time, try to eliminate or deal with it, such as the small fault can not be eliminated, or when a big fault is found, it should be checked immediately.
5, in addition to each d透水地坪emolition, should be replaced with lubricating oil, should also be replaced regularly.
6, E type transmission bearing block should be checked regularly (Ji Du), cleaning and adding lubricating oil to prevent bearing burn out.
辛苦整理！轉載請註明來自http://www.wxmlfj.com/faq/124.html