解析停車場环氧地坪漆的工藝簡單又高效原因

停車場环氧地坪漆的工藝流程：一、塗裝方案設計在瞭解瞭基材狀況、环氧地坪使用要求後，需要對环氧地坪工程進行塗裝方案設計.內容包括： 1、表面處理方式：即針對現實存在的其材狀況，采用什麼樣的表面處理方式2、塗層厚度，包括總塗層厚度及各道塗層的厚度設計;3、宜選用的停車場环氧地坪漆塗料及輔料品種，包括底漆、中塗層、面漆等，還有各種粒徑的石英砂、稀釋劑、清洗劑等輔料; 4、各道塗層或工序的施工方法; 5、進行各道工序施工需要的設備、工具及耗材等的配置; 6、施工人員及施工進度安排等。 7、施工過程中的質量控制和檢測手段; 8、环氧樹脂砂漿滾塗地坪順序如下： a.基面打磨除塵處理。 b.塗刷环氧樹脂封閉底漆。 c.批刮环氧樹脂砂漿地坪漆。 d.批刮环氧樹脂地坪膩子。 e.塗刷环氧樹脂面漆。 f.塗刷环氧面漆或清漆。
The process flow of parking lot floor paint: 1. After knowing the condition of base material and the requirement of epoxy floor, it is necessary to design the coating scheme for epoxy floor project. T环氧地坪he contents include: 1. Surface treatment method: which surface treatment method should be adopted according to the actual material condition; 2. Coating thickness. Degree, including the total coating thickness and the thickness design of each coating; 3. The suitable types of parking floor paint and accessories, including primer, intermediate coating, topcoat, and other accessories, as well as quartz sand, diluent, cleaning agent of various sizes; 4. The construction methods of each coating or process; 5. The construction needs of each process. Configuration of equipment, tools and consumables; 6. Construction personnel and construction schedule. 7. Quality control and testing methods in construction process. 8. The sequence of roll-coating floor with epoxy resin mortar is as follows: a. Base surface grinding and dust removal treatment. B. brushing epoxy resin seal primer. C. batch of epoxy resin mortar floor paint. D. batch scraping epoxy floor putty. E. brushing epoxy resin finish. F. coat epoxy varnish or varnish.
? 二、素地處理是环氧地坪施工
Two, prime land treatment is epoxy floor construction.
??混凝土地面，表面處理及素地缺陷修復 1、 混凝土素地質量評估 混凝土素地澆鑄質量是地坪質量的基礎，一般要求是看上去平整、堅實、不易起沙、敲擊時聲音清脆，一般磨刮不輕易留深痕，表面上下一致，無明顯松散，用小錘敲擊，無空殼聲，表面檢查，無較大面積裂縫，無龜裂現象，即可判為基本合格。 基層檢查包括混凝土含水率的測定、平整度的測定、強度的測定。
_Concrete ground, surface treatment and repair of defects in plain ground 1. Evaluation of plain ground casting quality of concrete is the basis of the quality of the ground. Generally, it is required to look flat, firm, not easy to sand, and sound when knocking is clear. Generally, it is not easy to leave deep marks when scraping, and it is consistent on the surface, without obvious looseness. With hammer knocking, no shell sound, surface inspection, no large area cracks, no cracking phenomenon, can be judged to be basically qualified. The basic level inspection includes the determination of the moisture content of concrete, the measurement of evenness and the determination of strength.
? 三、停車場地坪漆的註意事項及選擇方法
Note three, matters needing attention and selection methods for parking floor paint
??(一)、 混凝土強度必須≥C25.含350kg/m3以上的普通矽酸鹽。 水泥及水灰比 (二)、透水地坪 找平層必須是細石混凝土及其厚度不可少於50mm。
(1) the strength of concrete must be equal to more than C25. of ordinary silicate containing more than 350kg/m3. Cement and water cement ratio (two), leveling layer must be fine aggregate concrete and its thickness can not be less than 50mm.