如何保證熱風爐可以更加的節能

由於傳統的燃煤熱風爐屬於老式的產品，而且其在技術上比較有限，所以在整個生產的過程中，會產生較多的廢氣、廢渣和廢水，並對环境造成嚴重的污染，這點對环保在治理方面工作帶來瞭較大的影響，因此，這些傳統的老式燃煤熱風爐將逐步的淡出行業。而取而代之的环保型熱風爐，將劣勢直接的轉換成的優勢，並在整個效率上做出最大的提升，主要的表現可以分為以下五點：
Because the traditional coal-fired hot blast stove belongs to the old-fashioned product and its technology is relatively limited, in the whole production process, it will produce more waste gas, waste residue and waste water, and cause serious pollution to the environment, which has a greater impact on the environmental protection in the governance work, therefore, these traditional old. The type of coal-fired hot blast stove will gradually fade out of the industry. Instead, the environment-friendly hot blast stove directly converts the disadvantages into advantages and maximizes the overall efficiency. The main performance can be divided into the following five points: 一、開展並引導熱風爐在燃煤的能耗上，進行指標方面的降低競爭；
1. Develop and guide the hot-blast stove to reduce the competition in the energy consumption of coal-burning and in the aspect of indicators;
二、對熱風爐在負荷方面進行有效的控制，盡量的避免熱風爐的運行過程中出現結焦的現象；
2. Effective control of the load of the hot blast stove to avoid coking during the operation of the hot blast stove as far as possible.
三、將熱風爐在燃燒的形式上進行優化，並降低其整體的損失；
3. Optimize the combustion form of hot blast stove and reduce its overall loss.
四、控制熱風爐在水汽方面的主要品質要求，將熱風爐在排污率上進行有效的降低；
4. Controlling the main quality requirements of hot blast stoves in water vapor and effectively reducing the discharge rate of hot blast stoves;
五、及時有效的對熱風爐在負荷上進行調整。
Fifth, timely and effective adjustment of hot stove load.
節能熱風爐從出現到現在，在整個市場的反环氧地坪響還是很不錯的，屬於新型的环保型熱風爐，而且還具備瞭較多的優點，由於節能的熱風爐不存在凝結水，以及二次蒸發所帶來的損失，所以利用其進行熱水的供暖，至少可以節省20％-40％左右的燃料。
Since the emergence of energy-saving hot stove, the response in the whole market is still very good, belongs to a new type of environmental protection hot stove, but also has more advantages. Because there is no condensate water in the energy-saving hot stove, and the loss caused by secondary evaporation, so using it to heat hot water can save at least 20%. About - 40% of the fuel.
而且由於節能的熱風爐在熱水的供暖的管道上，可能出現的散熱損失是非常小的，並能夠非常靈活的對熱水在質量方面進行控制和調節，不僅可以有效的對燃料進行節省，還能保證整體的供熱需求不受影響，所以這款熱風爐的發展還是非常樂觀的。
And because the heat loss of the energy-saving hot stove in the hot water heating pipeline is very small, and it can control and adjust the quality of hot water very flexibly, not only can it save fuel effectively, but also can ensure that the overall heating demand is not affected, so the hot stove's. Development is still very optimistic.
節能的熱風爐在高溫的熱水供暖系統上，需要使用到的維護費用是非常低的，相對來說熱水的供暖在熱半徑上比較大，至少可以滿足幾十公裡左右的供熱，因為采用的是集中的供熱系統，所以在燃料的節省上也比較明顯，還能降低對印花地坪环境造成的污染。
The maintenance cost of energy-saving hot-blast stove in high-temperature hot-water heating system is very low. Relatively speaking, hot-water heating has a relatively large thermal radius, which can meet the heating needs of tens of kilometers or so. Because of the centralized heating system, the fuel saving is also obvious, and it can also meet the needs of energy-saving hot-blast stove. Reduce environmental pollution.