环氧自流平地坪施工工藝及施工註意事

相信很多的公共場所都喜歡使用环氧地坪漆,而且也都覺得十分的好用,這個時候就會有很多人都想要瞭解环氧地坪自流平施工工藝,环氧地坪自流平施工註意事項都有什麼?接下來就按照大傢的要求簡單的介紹一下,希望可以幫助到消費者的需求。环氧地坪自流平施工工藝,环氧地坪自流平施工註意事
I believe that many public places like to use epoxy floor paint, but also feel very useful, at this time there will be a lot of people want to understand the epoxy floor self-leveling construction technology, epoxy floor self-leveling construction matters needing attention? Consumer demand. Epoxy floor self leveling construction technology, epoxy floor self leveling construction matters needing attention
环氧地坪自流平施工工藝
Self leveling construction technology of epoxy floor
基礎處理:依素地狀況做好修補,打磨,除塵,經處理後,环氧地坪表面平整、密實、幹燥,無油污、且沒有松動易碎顆粒,方可進行下一工序施工。
Foundation treatment: Repair, grinding and dust removal are done according to the condition of plain land. After treatment, the surface of the floor is smooth, compact and dry, no oil pollution, and no loose and fragile particles, then the next process construction can be carried out.
自流平底漆:采用封閉性及附著力特強环氧底漆滾塗一道,增強表面附著力;
Self leveling flat paint: the sealing and adhesion of the epoxy primer is coated with a roller to enhance the surface adhesion.
自流平砂漿中塗:將环氧樹脂加入適量的石英砂,用鏝刀环氧地坪將其均勻塗佈數道,施工交接處理是否妥當,踢腳線位置平直,與墻壁無離間,平整。
Self-leveling mortar intermediate coating: epoxy resin into a suitable amount of quartz sand, with a trowel evenly coated several channels, construction handover treatment is appropriate, the kick line position is straight, and the wall without separation, flat.
环氧膩子:用环氧膩子施工兩道,使地面完全平整無孔洞,無批刀印及砂磨印方可進行面塗層施工。
Epoxy Putty: Use epoxy Putty to construct two ways, so that the ground is completely smooth without holes, no batch knife printing and sanding printing can be carried out surface coating construction.
环氧自流平面漆:用自流平面漆均勻鏝塗一道,完工後整體地面達到光亮潔凈,顏色均一,無空鼓,註意先後施工交接處的處理;塗層要求均勻,無流掛,無針孔、光潔、平整。
Epoxy self-flowing surface paint: use self-flowing surface paint uniformly coated one, after completion of the whole ground to bright and clean, uniform color, no empty drum, attention to the construction of the junction of the treatment; coating requirements uniform, no hanging, no pinholes, smooth and smooth.
环氧环氧地坪自流平施工註意事項
Matters needing attention in self leveling construction of epoxy floor
雨期施工:如空氣濕度超出施工條件時,應增加人工排風設施(排風扇等)控制濕度。遇大雨、高濕度等天時應停止施工。
Construction in rainy season: If the air humidity exceeds the construction conditions, artificial ventilation facilities (exhaust fans, etc.) should be added to control humidity. Construction should be stopped in case of heavy rain and high humidity.
樹脂整體面層施工時,环境溫度不得過低、過高,濕度不得過大,防止樹脂砂漿產生假固化。
During the construction of resin monolithic surface, the ambient temperature should not be too low, too high, and the humidity should not be too high to prevent resin mortar from producing false solidification.
施工場所應註意通風良好。
Construction site should pay attention to good ventilation.
施工中塗料避免接觸皮膚,雙手能有保護手套。
During construction, paint should avoid contact with skin and hands can have protective gloves.
施工中玷污處要清洗幹凈,施工後順將場地、垃圾清除完畢。
In the construction, the stain should be cleaned, and the site and rubbish will be cleared after construction.
地面灰塵須徹底清除,以確保底漆之接著效果。
Ground dust must be thoroughly removed to ensure the subsequent effect of the base paint.
地面潮濕時須使之幹燥,含水率8%以下,或者選用特殊底漆。
When the ground is wet, it must be dried, moisture content below 8%, or special primer.
环氧樹脂的各層塗料若出超出有效接著地間,須將材料表面打粗並處理幹凈,塗上一層底漆(依間隔時間長短),再進行上層塗料施工。
If the epoxy coatings exceed the effective next floor, the surface of the material must be roughened and treated clean, coated with a primer (according to the interval time), and then the upper coating construction.
底漆須待完全揮發後方可進行施工,以免起泡現象。
The primer must be completely evaporated before it can be constructed to avoid foaming.
材料調配時,須以底佈(或紙板)墊底半避免任何一種材料單獨滴於素地上,造成不幹,若已滴於素地上時須立即擦去。
Material deployment, to 彩色沥清地坪the bottom of the cloth (or cardboard) to avoid any material alone dripping on the vegetable ground, resulting in non-drying, if dripping on the vegetable ground must be immediately erased.
攪拌後的材料應在可使用時間內塗佈完畢,避免表面接近硬化無法流平。
After mixing, the material should be coated in the available time to avoid surface hardening and no leveling.
塗佈發現砂粒或其它雜質時,立即清除。
When coating is found, sand grains or other impurities are removed immediately.
环氧樹脂防塵耐磨地坪施工時應註意其混合比例,混合攪拌均勻才可使用。
Epoxy resin dust-proof floor construction should pay attention to its mixing ratio and mix and stir evenly before it can be used.